Return to the Heating & Air Conditioning Forum | Post a Follow-Up

2 cold-air returns in small apartment; can I block one?

Posted by dcc32 (My Page) on
Thu, Nov 15, 12 at 16:02

I live in a pretty strange basement apartment, built mid 1950s or so, that has a lot of strange heating issues that are costing me money. Before I get to my question, let me describe how this system seems to be set up.

My apartment is a 700 sq ft garden level, so I have nice windows in all of my rooms. However, my floor is a carpet covered concrete pad. My ductwork seems to be *below* the pad, since the heater vents are the kind of old fashioned ones that are up against the base of the wall, and I have found all the nice warm places in the floor via my heat-seeking cat. By the time the air leaves the ducts, it is perhaps 70 degrees--pretty tepid for just having come from the heater. There are two cold-air returns, a smallish one in the bedroom and a larger one in the living room. Both are near the ceiling, which I suppose makes sense--air is sucked through the top of the heater and blown out the bottom. Well, it makes sense as long as you don't believe in physics...

My problems are numerous, but the biggest one right now has to do with the big return. There is a TON of cold air that seeps out into my living room/workspace. If I have space heaters running, the temperature differential sucks up all my warm air that is accumulating near the ceiling, even if the heater isn't active taking in air (between cycles). Additionally, I shined a flash light into the grate to see what's going on...there is no definite ductwork, and I can see water pipes and floor beams, in addition to some ductwork-looking metal. I can't see what's happening in the small return because it is kind of dirty (I'm in the process of cutting through the many layers of paint so I can wash it and also continue my sleuthing). Either way, the small one doesn't seem to seep cold air in the same way that the big one does.

This is my question: Can I close off the bigger return so that I keep my space-heated air from being sucked away/close off the seeping cold air? The house is super drafty, so I'm not that worried about pressure problems. Also, I kind of assume that the heater can just suck its air from wherever all that dratted cold air is coming from.

This is a rental in a city with strict building codes, where the rentals are managed by companies with 1000+ properties that are mostly rented to students (i.e. service is bad), so I am kind of limited and I'm just trying to make do with what I have. I've already caulked up everything I can see in an attempt to halt as much cold air as possible! Thanks!

Follow-Up Postings:

RE: 2 cold-air returns in small apartment; can I block one?

No. Closing off the larger return will starve the system of airflow, which may cause the furnace (I'm assuming gas) to cut off on an high-temp safety switch. The system may be lacking enough airflow as it is -- many systems have undersized return air ductwork. The furnace needs to move enough air over the heat exchanger to prevent damage to the furnace heat exchanger and a potentially dangerous situation.

RE: 2 cold-air returns in small apartment; can I block one?

It sounds to me like your duct system has leaks that cold air is getting into your system. Even if your ductwork is in concrete it should not drop your air temp that much unless cold air is getting in also.

I would start with temperature readings of the return air temp at the return compared to the actual return air temp at the furnace. I would then check the supply temp at the furnace right after being heated and compare it to the supply temp.

You might have to put some small holes in at the furnace so don't forget to seal them.

 o Post a Follow-Up

Please Note: Only registered members are able to post messages to this forum.

    If you are a member, please log in.

    If you aren't yet a member, join now!

Return to the Heating & Air Conditioning Forum

Information about Posting

  • You must be logged in to post a message. Once you are logged in, a posting window will appear at the bottom of the messages. If you are not a member, please register for an account.
  • Please review our Rules of Play before posting.
  • Posting is a two-step process. Once you have composed your message, you will be taken to the preview page. You will then have a chance to review your post, make changes and upload photos.
  • After posting your message, you may need to refresh the forum page in order to see it.
  • Before posting copyrighted material, please read about Copyright and Fair Use.
  • We have a strict no-advertising policy!
  • If you would like to practice posting or uploading photos, please visit our Test forum.
  • If you need assistance, please Contact Us and we will be happy to help.

Learn more about in-text links on this page here