Return to the Renewable Energy Forum | Post a Follow-Up

Best roof for solar panels

Posted by ylmzm (My Page) on
Thu, Aug 29, 13 at 14:27

We recently bought a house. The roof is in bad condition and we will have it replaced soon. We also plan to install solar panels in a few years.

What is the best roof material for solar panel installation? We decided to install Certainteed Lanmark Permium shingles. Does the roof color matter? And how about solar panel supports (for mounting brackets) that should be installed on the roof? Is it a better idea to install those supports now ?

Follow-Up Postings:

RE: Best roof for solar panels

I look forward to the responses. It may be that a standing seam metal roof where the PV panels can be clamped into place without any fastener penetrations into your roof might be a candidate for "best".

RE: Best roof for solar panels

Depending on the point of view.

Since most roofs are asphalt shingled, solar installers would be very familiar with the installation. Some prefer to work with asphalt shingled roofs.

Metal shingle roofs require more care, but will last much longer than asphalt shingles and reduce the solar heat gain in the attic.

Clay tile roofs could be really problematic for some solar installers.

In any case, the mounts have to be treated as plumbing vents and flashed accordingly.

For metal shingle roofs, there are no direct penetration mounts which can be used. The fasteners are not exposed at all.

Standing seam roofs with non penetrating mounts are also a very good option.

If you're concerned about the solar heat gain, use a cooler color or more IR reflective roof material.

Solar electric generation also declines with increased temperature.

You could have the mounts installed first. In some counties, new homes have to be constructed PV ready - mounts are required.

RE: Best roof for solar panels

When installing new solar roof panels on an existing home or building, consider replacing any roof older than 10 years - especially if it's an asphalt shingle roof. Pick a roof to which solar panels can be mounted without leak-prone holes in the roof material. Metal roofs are the lightest, longest-lasting roof materials, and can accept solar panels without having holes punched through their protection. Installing a good quality metal roof before your new solar power system is mounted will mean never having to replace the roof.

RE: Best roof for solar panels

Think about durability of the roof. You want your roof to last longer than your solar panels, as you don't want to have to remove the panels, then change the roof and reinstall the panels...that's a lot of work. We have a 50 yr asphalt shingle roof under ours.

RE: Best roof for solar panels

I would always go metal in these applications.

Its permanent and the metal roof will keep the surface temperatures lower as compared to asphalt over the length of the day.

The thin film solar applications for standing seam don't have near the efficiency of the panel systems.

roof noise

Just a note...

We had a skylight installed in a cathedral ceiling in our master bedroom,
(open beam with no attic space)

This was right over our bed and turned out to be a poor idea.

In addition to the bright full moons the rain was very noisey.
We had it removed.

Wonder how loud rain might be on a metal roof?

This post was edited by bukzin on Wed, May 21, 14 at 9:49

RE: Best roof for solar panels

Not a problem.

Most metal roofing solutions are stone coated which helps deaden the sound.
The tiles are laid on top of a fairly solid and thick plywood or osb subroof with the requisite waterproofing membrane in between. Depending on the manufacturer's instructions, the tiles could be installed with or without battens.
In addition, there will usually be an insulated attic space.

For standing seam roofs, the metal will be backed by plywood or osb with a waterproofing under layment between which deadens the sound.

On the other hand, if the roof is corrugated sheet metal with minimal support and no insulating barrier separating the usual living space,yes, it will be noisy.

RE: Best roof for solar panels

>> Wonder how loud rain might be on a metal roof?

Wonderfully loud, and actually soothing. Yes, I have lived in a corrugated metal roof house with terrible insulation where the terne was laid on lath, vaguely like barrel tile.

Actually, since there are so many things that can come between a metal skin and your bedroom ceiling, one can't really answer that question in any meaningful way without a lot of details, but in a nutshell, davidtay's answer is gold..

 o Post a Follow-Up

Please Note: Only registered members are able to post messages to this forum.

    If you are a member, please log in.

    If you aren't yet a member, join now!

Return to the Renewable Energy Forum

Information about Posting

  • You must be logged in to post a message. Once you are logged in, a posting window will appear at the bottom of the messages. If you are not a member, please register for an account.
  • Please review our Rules of Play before posting.
  • Posting is a two-step process. Once you have composed your message, you will be taken to the preview page. You will then have a chance to review your post, make changes and upload photos.
  • After posting your message, you may need to refresh the forum page in order to see it.
  • Before posting copyrighted material, please read about Copyright and Fair Use.
  • We have a strict no-advertising policy!
  • If you would like to practice posting or uploading photos, please visit our Test forum.
  • If you need assistance, please Contact Us and we will be happy to help.

Learn more about in-text links on this page here